Power of Ice - Sliding Ice & Snow Causes Roof & Property Damage

Located in Big Sky, Montana, the Arrowhead Condominium Association consisted of 24 units with metal roofs and a 12:12 slope.  These homes are only 10’ to 15’ apart, and each is a ski-in/ski-out unit on a hillside.  During harsh winter weather, the snow, ice dams, and icicles were sliding off the units and damaging neighboring homes.  The front door of one unit even collapsed three different times.  The decks on the buildings had to be closed for the winter, since many rails and decks had been torn off.  On lower shed roofs, not only was the metal roofing torn and bent, but the ¾” plywood sheathing was crushed between the roof’s rafters.

On several occasions, Ryan had worked with the Association’s insurance company assessing the damage.  The insurance company said it would not renew its policy due to the continuing problems.  “Their concern of the ice and snow killing someone was too great,” noted Ryan, “We did not know how to eliminate these problems, so we called Locati Architectures of Bozeman, Montana. They referred us to Terry Anderson of Anderson Associates Consulting, Inc.”

Anderson, who is the co-author of The Cold Roof Manual, published by the Western State Contractors Association and the Roof Tile Institute (RTI), visited the project to review all the damage and concerns.  He concluded that the only way to solve the problem was to stop the movement of ice and snow.

“Anderson recommended an engineered snow-retention system,” Ryan continued. “He also recommended a good ventilation system that, once installed,

 would stop most of their ice dam and icicle problems.  He visited with the board and gave them several roof options.  After reviewing the choices, the Arrowhead Condominium Association chose concrete roof tiles.  The association felt the concrete tiles had the longest record

 of use in Europe using a cold-roof design.  They also liked the look of the tile.”

After Anderson Associates wrote the specifications and details, the project was bid out to qualified roofing companies who were familiar with the specified cold-roof system.  Trojan Roofing, from Salt Lake city, Utah, was selected.  The choice of all parties was concrete tile produced by Westile, Inc. of Denver, Colorado.

Since ground snow loads increased after the units were built, Anderson Associates hired a local engineering firm to check the structural integrity of the building for retaining snow and ice on the roof.  Securing the rafters properly to the plate-lien and purlins was the only minor change that was required.

Because it was late in the year and winter was approaching, the Arrowhead Association chose 14 of the 24 united to be reroofed immediately.  It was difficult for Trojan Roofing to work in the cold and snow conditions, but it gave all involved a great opportunity to see the difference between the old and new systems. 

Many of the homeowners were concerned that the building could not retain snow on a 12:12 slope.  Anderson worked with the homeowners, assuring them that with proper engineering of snow fences and snow brackets, the roof system would retain the snow and ice on the roof.  The system was designed using a fully engineered snow-retention system with TRA Snow Brackets.

“Neither the homeowners nor the association understood what a cold-roof system was and how it would stop ice dams and icicles” stated Anderson.  “We worked very closely with them, explaining that venting air below the roof tile and above the sheathing would make melting and freezing equal from eave to ridge.  We used the RTI and WSRCA Cold Roof Manual and air ventilation charts from Europe.”

Since adequate ventilation was critical to the success of the roof system, Anderson calculated the air-duct size needed from eave to ridge.  He then designed an air-intake system from the eave and a ridge exhaust system in a raised-ridge vent.  Everyone involved was pleased to see the major difference from the old to new system, which was immediately apparent when icicles were eliminated and snow was retained on the roof.

Homeowners of the first reroofed units were very pleased with the results.  The owners commented on how exceptional the tile looked with all the copper flashing and the copper TRA Snow Brackets.  The real proof of the improvements between the two roof systems became clear as the snow began to fall; the difference in the two roof systems was obvious.  The newly designed cold-roof system allows the snow to compact naturally with ice in the bottom 3”.  This ice freezes around the triangular portion of the TRA Snow Bracket.  This permits the natural run-off of water to shed between the ice and the roof tile when the outside temperature was above freezing.  Photos were taken to show the other property owners, who are all over the U.S., the improvements.

“The new units have stopped all snow and ice movement as well as icicles,” stated Ryan.  “The old units still have leaks, icicles, ice dams, damaged decks and snow and ice hazards.  Our association and homeowners are very happy with the look and design of the units.  We are looking forward to having the last ten units completed this spring and summer.  Retaining the snow on the roof has also reduced the heavy snow-removal cost.”

According to Ryan, “Credit needs to go to Anderson Associates Consulting, Western State Roofing Contractors Association and the Roof Tile Institute for the work on the Cold Roof Manual that made this system possible as well as the great work done by Trojan roofing while working in such bad winter snow and ice conditions.  The units look beautiful; they are safe and insurable,” concluded Ryan.